it look bad but its mine! (restoration process)

[Ndelilio Nnko]

my mechanics help me to remove air in the break!

 

[Janko]

The muffler is fine, it probably has wonderful voice!

 

[pepper]

Great story, I love the colour of your car.

Here in the UK we just change the whole slave cylinder when they are leaking like that as it's normally down to lots of rust ruining the sleeve allowing the brake fluid to get past the seal on the piston in the slave cylinder, the rubber covers on the ends are only to prevent dust and dirt contaminating the piston as it comes out of the cylinder.

I hope your mechanic sorted out the leak and didn't just change the rubber covers!

 

[pepper]

There's a diagram showing a basic type of slave cylinder.

 

[Ndelilio Nnko]

Hi pepper, thnx for your knowledge, i wish one day to change all slave cylinder they are already old enuf to be changed! my mechanics solve all the problem of leak! now l enjoy my ride

 

[Ndelilio Nnko]

It was holiday of eid mubarak, l decided to go to local garage to repair my chasis, it have been melted with rust! no one have been take a good care of this car

 

[Ndelilio Nnko]

mechanics start to replace this part by welding it (is it stablizer or what? dnt know its name) to its place!

 

[Ndelilio Nnko]

mechanics use iron sheet gauge 28 to reinforcement chasis......

 

[Ndelilio Nnko]

That iron sheet we replace it to the chasis and start to welding it.

 

[Ndelilio Nnko]

its a local job but mechanics charge me alot of money!

 

[Ndelilio Nnko]

l finish my project by went to buy red oxide to prevent rust.
l start to paint that chasis

 

[pepper]

Ouch, looks like it's rust with a bit of fatigue.

 

[petak]

It must got hit with road rock there. Or fell into some hole.

Brake is to big to be only from rust.

 

[Ndelilio Nnko]

Yes Petak i admit it, l drive one night in rough road. l fell into hole, after reach home l notice there is a problem in my chasis

 

[Ndelilio Nnko]

Jambo! l decided to test my car in rough road to check the strongness of that chasis which mechanics repair...... l start to drive from Arusha City to Nelson Mandela Institute of Science and Technology. half of road is rough road, when l drive l did not experience any problem.
l attach pic when l was at The Nelson Mandela lnstitute

 

[Ndelilio Nnko]

Early in the morning l take my R4 to the market to sell my vegetables.. when l come back from market l notices my fan of radiator is not working....

 

[Ndelilio Nnko]

when l reach home l start to open fan and found that the wire was disconnected.
The arrow show the wire that disconnected that make fan not working.

Take a look.......

 

[Ndelilio Nnko]

l went to friend of mine he is electrical mechanics and help me to solder it..

The pic with arrow show the relapcement of new wire,

 

[Ndelilio Nnko]

l start to reassemble all parts so that l can fix it with radiator

 

[Ndelilio Nnko]

After few minutes l finish to reassemble, l start to fix to the radiator and connect wires....

l start my engine and fan start to run,

problem solved